Page 10 of 11

Re: let the games begin - R69s engine rebuild

Posted: Tue May 04, 2021 4:03 pm
by jwonder
It is looking very nice!! Good job!

Re: let the games begin - R69s engine rebuild

Posted: Tue May 04, 2021 4:29 pm
by malmac
jwonder wrote:
Tue May 04, 2021 4:03 pm
It is looking very nice!! Good job!
James

It has been a bit of a slog and not quite there yet.

I have a complete head and rocker gear rebuild in the pipeline.
However first up I am going to run the new pistons and bottom end and get that bedded in and then I will backtrack to do the top end.

I actually have two R69s motors, so I may do up the heads off the other motor and when they are ready do a quick swap job.
I am doing the same with the gearbox. This bike currently has gearbox 2 installed. When I have rebuilt gearbox 1 I will swap out gearbox 2.

I guess I am working with what options I have.


Mal

Re: let the games begin - R69s engine rebuild

Posted: Thu May 06, 2021 3:54 am
by malmac
MAL_1446 1.jpg
Well getting close.....

Fuel lines, fuel, timing and connect generator, check the valve clearances and a general check over.

Who knows it might get a kick soon.


Mal

Re: let the games begin - R69s engine rebuild

Posted: Sat May 08, 2021 12:56 am
by malmac
THE FINAL POST FOR THIS THREAD

Well did the engine timing, fresh fuel etc.

With fuel and ignition off I gave the old fella some kicks to get the oil pump at least primed.
Ignition on, fuel on, 10 seconds on the carbs, two kicks and he was up and running.

Carbs need to be fine tuned and there are other little bits and pieces but he's back together and rode him around the block quite smooth, no nasty noises etc.
14 months and that part of his refurbishment is complete.

Here is my little home made buzz box for static engine timing.
MAL_1457.jpg
Riding around the block, which is just the local playing field.
PG9_1011.jpg
You cant see the smile but I could barely fit it in my helmet.
PG9_1013.jpg
Here he is after his short test ride.
MAL_1451.jpg

I hope you were able to learn something from my rebuild, I know I certainly did.

Re: let the games begin - R69s engine rebuild

Posted: Sat May 08, 2021 7:53 am
by Daves79x
Excellent! All of your hard work has paid off. Also, congrats on the excellent article in the latest magazine!

Dave

Re: let the games begin - R69s engine rebuild

Posted: Sat May 08, 2021 8:35 am
by skyler.robbins
Great job Mal!
This is without a doubt been the most enjoyable story to follow here on the forum.
I was also glad to see the recent article in the magazine!
Enjoy riding the bike!

Rob

Re: let the games begin - R69s engine rebuild

Posted: Sat May 08, 2021 3:08 pm
by malmac
Daves79x wrote:
Sat May 08, 2021 7:53 am
Excellent! All of your hard work has paid off. Also, congrats on the excellent article in the latest magazine!

Dave
Dave

thank you for several suggestions you have made. They are always taken seriously and usually I benefit greatly.
As for the article, if it was readable then thank James Wonder and editorial team for turning my incomprehensible ramblings into a readable article.

Mal

Re: let the games begin - R69s engine rebuild

Posted: Sat May 08, 2021 3:12 pm
by malmac
skyler.robbins wrote:
Sat May 08, 2021 8:35 am
Great job Mal!
This is without a doubt been the most enjoyable story to follow here on the forum.
I was also glad to see the recent article in the magazine!
Enjoy riding the bike!

Rob
Rob

Thank you for the positive feedback. Regarding the recent article which took James a lot of time to beat into order, maybe there might be a follow up article if James is up to the task. We will see.

Cheers

Mal

Re: let the games begin - R69s engine rebuild

Posted: Sat May 08, 2021 9:12 pm
by Slash2
Always fun checking in on your progress. Congratulations on getting her, excuse me, “him” back on the road. I have a feeling that engine will now be capable of a few hundred thousand miles without much fuss.

Re: let the games begin - R69s engine rebuild

Posted: Sat May 08, 2021 10:01 pm
by malmac
Slash2 wrote:
Sat May 08, 2021 9:12 pm
Always fun checking in on your progress. Congratulations on getting her, excuse me, “him” back on the road. I have a feeling that engine will now be capable of a few hundred thousand miles without much fuss.
He is a him and his name is Wolfmuller and my other bike is called Hilderbrand.
All so obvious when you think about it.

Mal